PCM 302 bogging down

Hello all - I have a 1980 302 Ski Tique, it has been running awesome for the past 2 years, specially after having the carb completely rebuilt.  So over the weekend we went out to take my son waterskiing and I completely neglected the fuel gauge....tank was pretty much empty...needless to say I had to call one of my neighbors to tow us back in.  So I figured I would get 5gl in the tank and get back out there..well not so fast.  It took forever to start the motor to the point I completely drained the battery.  She wouldn't start period.  Finally got her to start, idle was ok.. we get back out on the water and now she's bogging down and running rough.

I'm not sure whats going on...so I recall reading about fuel line collapsing?? Could that be the issue? Can I use a 5gl gas can to bypass the tank?

any other thoughts?  Like I said, she has been running awesome until running out of gas

thanks in advance!

It sounds like you sucked some junk in the tank into the anti siphon valve or into whatever filter you have in the fuel system and it's not getting enough gas under load.

The suction hose probably didn't decide to collapse at the same time you ran out of gas 

You could hook a portable tank to the fuel pump like you mentioned for troubleshooting. The tank needs to be vented so you don't draw a vacuum 

If it runs good on the tank, then your problem is before the fuel pump.

If it still runs bad, you probably got junk in the carburetor or the fuel pump itself.

PS..........an easy way to start an engine that ran out of gas is to squirt a little gas down the primary barrels of the carburetor, then turn the key. You may have to repeat it a few times till the engine stays running but it gets gas to the carburetor bowls a lot quicker this way.

About a tablespoon at a time is good and putting the flame arrestor back on each time keeps you safer

The fuel pump has a hard time sucking from the tank and filling the line to the carburetor when the engine is turning over slow without starting so the prime you give it, kicks the engine over and the pump is operating faster and sucks better

^^^^^^^^  Best tip ever.  This is how I bring my boat up after storing it for the winter and the key point *PUT THE FLAME ARRESTOR BACK ON CARB EACH TIME.  Don't ask me how I know about this.........